Service Department Offerings
Flat Rate Pricing for 2010
Bottom Prep and Paint
Remove Bottom Paint |
$145.00/foot of LOA |
Remove Bottom Paint, Apply Barrier Coat and Bottom Paint |
$220.00/foot of LOA |
| Remove Bottom Paint, Apply Barrier Coat, Sand and Apply Race Bottom |
$255.00/foot of LOA |
|
Up to 29' |
30' - 39' |
40' - 45 |
46' Plus |
Prep/Paint VC-17 |
$19.00 |
$20.00 |
$22.00 |
$23.00 |
Light Sand/Paint |
$20.00 |
$21.00 |
$23.00 |
$25.00 |
Prep/Paint w/*Premium |
$22.00 |
$23.00 |
$25.00 |
$30.00 |
Additional coats of *Premium (Micron CSC or Trinidad) are $15.00/ft. each.
Hull Sealant
|
Up to 29' |
30' - 39' |
40' - 45 |
46' Plus |
| Two Step Premium Wax System |
$18.00 |
$21.00 |
$22.00 |
$25.00 |
One Step Clean & Wax |
$12.75 |
$15.50 |
$18.00 |
$20.00 |
Superstructure & Decks |
Quote |
Quote |
Quote |
Quote |
Note: The above pricing is per foot of LOA (length over all) includes labor & materials.
Re-Commissioning Engines
Check all fluid levels & add fluid if required; Run engine; Check & tighten all belts; Check shift & throttle
mechanism; Test transmission; and make sure engine pumps adequate water for cooling.
1-3 Cylinders |
$80.00 each Engine |
4-6 Cylinders |
$90.00 each Engine |
| 8 Cylinders |
$100.00 each Engine |
Note: Vessel must have charged batteries installed.
Gas Inboard |
$95.00 |
Diesel IB 4 Cylinder or less |
$100.00 |
| Diesel IB 6 Cylinder or more |
$190.00 |
| Fuel Filter Change Only (each) Gas Engine only |
$20.00 |
| Fuel Filter Change Only (each) Diesel Engine only |
$40.00 |
| Transmission/V-Drive Fluid Change (each) |
$40.00 |
Note: Includes labor only. Oil, filters, etc. are additional.
Outdrives
Remove & Inspect; Grease; Install with New Gaskets; Drain & Fill |
$170.00 |
Inspect Water Pump includes: Remove, Grease, New Gaskets, Drain & Fill |
$200.00 |
| Drain and Fill Only |
$90.00 |
| Saildrive – Drain and Fill Only |
$90.00 |
Note: Includes labor & parts (excluding impeller if needed).
Gas Engine Tune Ups
Replace plug. Check plug wires, points, cap, rotor, timing & thermostat. Labor only, does not include any parts.
Worn or faulty parts will be replaced if necessary.
4 Cylinder Gas Engine |
$150.00 |
6 Cylinder Gas Engine |
$160.00 |
| 8 Cylinder Gas Engine |
$195.00 |
Prices are for labor only & do not include any parts.
Mobile Service
Experience the same quality of service you've come to expect at Manitowoc Marina, now at your slip. Mechanical, Electrical, Fiberglass Repairs & Rigging. Travel time billed @ $2.00/mile, distance from Manitowoc per day.
Winterizing Engines
Inboard Gas 3 Cylinder or Less |
$90.00 |
|
Diesel 4 Cylinder or Less |
$100.00 |
Inboard Gas 4 or 6 Cylinder |
$100.00 |
|
Diesel 6 Cylinder |
$150.00 |
Inboard Gas 8 Cylinder |
$110.00 |
|
Diesel 8 Cylinder |
$200.00 |
Outboard 20 hp or Less |
$55.00 |
|
Outboard Over 20 hp |
$85.00 |
Four Stroke Outboard Engines Additional $25.00
Note: Price includes Labor, Antifreeze & Fogging Oil (if required). Engines must be
operational with charged batteries on board. Internal antifreeze (closed system)
will be checked. Outboard Engines include fluid change.
Trailerable I/O Engine Winterizing
Package includes: Oil, Filter & Fuel Filter Change, Remove & Lube Lower Unit,
Fog Cylinders and Winterize …. $325.00 + Parts
Winterizing Water Systems
Basic Water System-One fixture |
$90.00 |
Additional Fixtures (each) |
$35.00 |
Deck Washdown |
$55.00 |
Head/Holding Tank System |
$50.00 |
Bilge Pumps |
$30.00 |
Air Conditioning & Heating System |
$115.00 |
Icemaker/Refrigeration Unit |
$100.00 |
Appliances (Dishwasher, etc.) |
$115.00 |
Note: Above pricing includes antifreeze and is for each piece of equipment.
Shrink Wrap Services
20' or Less |
$17.50/ft |
31' to 35' |
$21.50/ft |
41’ to 50’ |
$25.50/ft |
21' to 25' |
$17.75/ft |
36’ to 40’ |
$23.50/ft |
51’ Plus |
$27.00/ft |
26' to 30’ |
$19.75/ft |
|
|
|
|
(Add $40.00 for a Zippered Door)
Note: Our Shrink Wrap is guaranteed for the Winter. The above pricing is
based on a per foot of LOA (length over all) and includes labor and materials.
Hull Refinishing
AwlGrip & AlexSeal Coatings are known for their durability, color retention and high gloss, and Manitowoc Marina has become very proficient in its use. That’s why we’re the team that creates the Perfect Reflection of Your Success!
Up to 30 ‘ LOA |
$175-$200 per ft. |
30’ to 35’ LOA |
$200-$225 per ft. |
35’ to 40’ LOA |
$225-$275 per ft. |
40’ to 50’ LOA |
$250-$350 per ft. |
50’ to 55’ LOA |
$275-$375 per ft. |
55’ & Up LOA |
Quote per ft. |
Custom Rigging & Splicing
1/8 - 7/32 Wire |
$15.00 |
1/4 - 3/8 Wire |
$20.00 |
Double Braid Splice |
$19.00 |
Core to Core |
$33.00 |
Taper Cover |
$22.00 |
Whipping |
$6.00 |
We can make and install new Lifelines, Halyards, Standing and Running Rigging for your boat.
Equipment and Storage Fees
|
30' or Less |
30' - 45' |
45' Plus |
Travelift |
$5.50/ft |
$6.60/ft |
$7.70/ft |
Pressure Wash |
$3.30/ft |
$4.40/ft |
$5.50/ft |
Gin Pole |
$2.00/ft |
$3.00/ft |
n/a |
Storage Bins |
$90.00 (10/1-6/1) |
$60.00 (6/1-10/1) |
Battery Storage |
$20.00/Battery |
Sail Storage |
$30.00/Sail Bag |
Outboard Motor |
$25.00/Season |
|
|
Boat Stand Rental
$25.00 - Powerboat |
$30.00 - Sailboat |
$100.00 - Maxi |
General Labor Rates
Service Labor Rate |
$80.00/hour |
Refrigeration & A/C |
$85.00/hour |
Boat Cleaning/Detailing @ $45.00/hour. Inquire about Contract Pricing
Service Department Contacts
Bob Krowiorz, Senior Service Coordinator
Dayna Kohlbeck, Service Coordinator
Gary D'Aoust, Electronics Supervisor
Fred Warner, Mechanical Supervisor
Jack Hall, Refinishing Supervisor
|
